![]() |
URGENT: bosch wont pump ADDED VID P3 - Printable Version +- 306oc - Peugeot 306 Owners Club & Forum (https://www.306oc.co.uk/forum) +-- Forum: Engines (https://www.306oc.co.uk/forum/forumdisplay.php?fid=16) +--- Forum: XUD Section (https://www.306oc.co.uk/forum/forumdisplay.php?fid=11) +--- Thread: URGENT: bosch wont pump ADDED VID P3 (/showthread.php?tid=11535) |
URGENT: bosch wont pump ADDED VID P3 - puglove - 03-03-2013 Right got a massive issue with my bosch and cant get hold of ruan so... My bosch wont pump fuel . when cranked over it wont pump any fuel through the injecter lines, iv taken the lines off and there is the slightest dribble from where the lines meet the pump. Now iv taken the Stop solinoid plunger out as advised by ruan , still the tinyest dribble, so iv taken the stop solinoid out completly and when cranked over fuel comes out the solinoid housing? WTF is going on with this pump??? RE: URGENT: bosch wont pump - Eeyore - 03-03-2013 Are there any chips or bits of bacon stuck in the fuel lines? Sorry for not being helpful... URGENT: bosch wont pump - Seb_Ryan - 03-03-2013 Is it standard or 11mm? RE: URGENT: bosch wont pump - Mrs puglove - 03-03-2013 i believe it is a standard pump ![]() RE: URGENT: bosch wont pump - puglove - 03-03-2013 Its 9mm . Iv got the lines off completly and still nothing. Yet getting fuel from the solinoid housing URGENT: bosch wont pump - Seb_Ryan - 03-03-2013 Delivery valves seized? Do u get it out of the holes if you take them out? RE: URGENT: bosch wont pump - puglove - 03-03-2013 Sorry what? Lol . Out of what holes? URGENT: bosch wont pump - Seb_Ryan - 03-03-2013 Where the fuel lines attach to the pump, if you take the bits off where the lines bolt onto? Get me? RE: URGENT: bosch wont pump - Tom - 03-03-2013 Hammer. RE: URGENT: bosch wont pump - puglove - 03-03-2013 Took it all apart valves are all good and free. Turned it over again. Still nothing RE: URGENT: bosch wont pump - samass - 03-03-2013 How far did you take it all apart? RE: URGENT: bosch wont pump - puglove - 03-03-2013 Take what apart? The injecter valve bits? Or the pump? Iv not had the pump apart fully but thats not to say it hasnt been before i got it URGENT: bosch wont pump - Seb_Ryan - 03-03-2013 Wonder if a seal etcs gone and there's no enough pressure, or vane pumps seized.. Mine did a similar thing but the shaft inside snapped and was only squirting like a little kid.. RE: URGENT: bosch wont pump - puglove - 03-03-2013 Just seems strange that it gets as far as the solinoid but wont go any further , this is doing my fecking head in now URGENT: bosch wont pump - Seb_Ryan - 03-03-2013 Not pumping enough by sounds.. Do you get it out of the holes delivery valves go into if u remove them? RE: URGENT: bosch wont pump - puglove - 03-03-2013 It wouldnt be that someone has wound the max fuel screw right out would it? RE: URGENT: bosch wont pump - Anton - 03-03-2013 Possibly RE: URGENT: bosch wont pump - puglove - 03-03-2013 Anyone got a pic that shows the max fuel in OE possion? RE: URGENT: bosch wont pump - Ricky - 03-03-2013 Give it a full turn and then see if it pumps fuel, if it does, tighten up the unions and then try and start, just be ready on the clutch in 5th just in case.. RE: URGENT: bosch wont pump - puglove - 03-03-2013 Dosnt look like its wond out RE: URGENT: bosch wont pump - Danny2009 - 03-03-2013 That's still got the security seal on so fueling hasn't been touched RE: URGENT: bosch wont pump - Ricky - 03-03-2013 I take it you have the wire attached to the solenoid? As there's no wire in that picture.. RE: URGENT: bosch wont pump - puglove - 03-03-2013 Iv took the internals out of the solinoid so effectivly its dosnt have one atm RE: URGENT: bosch wont pump - Danny2009 - 03-03-2013 You done a Lucas to conversion? RE: URGENT: bosch wont pump - puglove - 03-03-2013 Yeah iv taken the lucus off n put a bosch on RE: URGENT: bosch wont pump - Danny2009 - 03-03-2013 You put all the pipes on in the right place? Easy mistake to make RE: URGENT: bosch wont pump - puglove - 03-03-2013 Well im getting fuel right up to the stop so all the fuel in is right. What could i get the wrong way to couse this? RE: URGENT: bosch wont pump - Danny2009 - 03-03-2013 Ahh didn't read that bit, is it pissing out or still dribbling out? RE: URGENT: bosch wont pump - puglove - 03-03-2013 Got the tinest dripple from the injector line ports RE: URGENT: bosch wont pump - Danny2009 - 03-03-2013 Shame I'm so far away i would come and lend a hand You slackened the fuel banjo off at the back of the pump to see if diesel is getting in? Have you used a Bosch bracket |